- The older Yamaha gas golf carts are known for having bad connections on the barrel connectors on the small wiring. I would start with checking them by unplugging them and looking for any corrosion. A bad ignition switch can also cause intermittent starting problems.
What causes a golf cart to jerk?
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
Why does my electric golf cart hesitate?
If your cart does not start smoothly, hesitates before starting, or does not gain speed properly, these are all signs of a bad or damaged accelerator.
How do I know if my golf cart solenoid is bad?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
Why does my gas golf cart take so long to start?
Any number of things could be wrong: Starting system issues: battery low on cold cranking amps, bad/corroded/inefficient connections in system wiring, starter motor going bad.
Why does my golf cart jerk when I accelerate?
The most common problem here is likely an issue with the batteries. If the battery is low on power or doesn’t distribute power properly, then the cart may jerk as it accelerates. Messing up the clutch or the MCOR is going to cause your cart to become even more jerky.
Should you charge a golf cart after every use?
Still, golf cart batteries should be recharged after four hours of use. Nobody likes to be stranded. It takes several hours to re-charge golf cart batteries that have gone completely dead. To lengthen the lifespan of batteries, make sure they are fully charged before each use.
Where is the reset button on a Yamaha golf cart?
First, you’ll want to reset your motor. Get out your handy screw driver and work to uncover the motor itself. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor.
Also Interesting
How do I reset my Yamaha golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
How do you diagnose a golf cart problem?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.
- Test the wall socket where you charge your cart.
- Expose your golf cart batteries.
- Test the batteries for voltage.
- Replace dead batteries.
- Expose the motor for inspection.
- Reset the motor.
- Test the cart.
What are symptoms of bad solenoid?
4 Signs of a Bad Starter Solenoid
- Engine Doesn’t Crank or Start.
- No Clicking Noise When Trying to Start the Engine.
- Starter Spins Without Fully Engaging the Flywheel (Rare)
- Engine Cranks Slowly (Rare)
- Test the battery.
- Check That Power is Getting to the Starter Solenoid.
- Test the Starter Solenoid Itself.
How do you test a solenoid on a Yamaha golf cart?
First, turn on the ignition while looking for a reading on the smaller terminals. If nothing is appearing, then press on the accelerator. If the needle doesn’t move, then the problem is not with the solenoid. If it jumps and displays full voltage, then the solenoid is the problem and should be replaced with a new one.
What makes a gas golf cart start?
In a gasoline-powered golf cart, the engine starts when you step on the gas pedal, and it shuts off when you take your foot off the gas. That feature helps save gas, cuts down on emissions and helps keep the course quiet, too. Electric golf carts use batteries to power an electric motor.
Read More
Can you push start a gas golf cart?
Pushing an electric golf cart is simple because it has a ‘free wheel’ system. If the golf cart is gas-powered, you simply need to put it in neutral, so that it becomes ‘free wheel’ and can be moved without being powered.
Why does my Yamaha golf cart not start?
The solenoid is a cylindrical coil of wire that works as the magnet carrying an electric current. This is a very common reason for golf cart’s not starting. Battery currents run to the motor through the solenoids, and you should always hear the solenoids clicking every time you press down on the accelerator.