- How do you remove the speed limiter on a electric golf cart? Use a screwdriver—or in some cases a wrench—to loosen the tension on the governor’s springs. Locate the golf cart’s governor; you can find the governor by tracing the thickest cable running from the gas pedal.
How do I adjust the speed on my electric golf cart?
Basically, an electric speed governor can be controlled by a tiny metal rod that’s located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
How can I make my electric golf cart go faster without upgrading?
How to Make an Electric Golf Cart Faster Without Upgrades
- Wash Your Cart Properly.
- Inspect the Batteries.
- Refill the Battery Water.
- Check the Gas Pedal and Linkage.
- Measure the Tire Pressure.
- Charge Up Your Battery Unit.
- Lighten Up Your Cart’s Weight.
How do you turn off a speed regulator on a golf cart?
Look behind the governor to find a small metal rod that’s permanently attached to the club car and stretch your rubber band enough to connect it to that metal rod. Screw the plastic plate back in place. Once the plate is back in place, the governor is disabled.
Does an electric golf cart have a governor?
Considering electric golf carts don’t have governors like gas powered carts, the old-school method of simply removing the governor is not an option.
How can I make my golf cart governor faster?
If you find this rod, then your governor can be easily adjusted by accessing the cart’s inner workings. Simply adjust the cable coming from this metal protrusion, turning the nut counterclockwise to make the cable longer, effectively adjusting the cart’s governance to increase the overall speed.
How can I make my 48v golf cart faster?
6 Ways You Can Make a Golf Cart Faster
- Add More Torque to Your Golf Cart.
- Upgrade Your Golf Cart’s Motor.
- Improve the High-Speed Controller of the Cart.
- Add Better Golf Cart Tires.
- Use a Higher Powered Golf Cart Battery.
- Watch the Weight in Your Golf Cart.
How do I make my electric EZ Go golf cart faster?
Increasing the speed of your EZ Go golf cart can be done by reprograming your speed control at the dealer, upgrading your batteries, motor, or replacing your speed control. Upgrading these can increase your typical speed from 12 MPH to 19.5 mph or above depending on your modifications.
Is 30 mph fast for a golf cart?
What is the Average Golf Cart Speed? The average top speed of a typical golf cart without any upgrades is between 12 and 14 miles per hour. Without any sort of modification or upgrade on a golf cart, the top speed that you will be getting on a golf cart is about 14mph.
How can I make my 36 volt club car faster?
How to Make a 36 Volt Golf Cart Faster
- Remove any unnecessary additions, racks or parts on your golf cart.
- Power-wash your cart.
- Check the shaft under the ignition pedal.
- Put larger tires on the cart.
- Replace any old or worn-out parts that are causing the cart to move slower than it should.
How do you adjust the governor on a EZ Go electric golf cart?
Tighten the governor spring located in the engine of most golf carts to adjust your cart’s top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly.
How does a golf cart governor work?
By mechanically pulling the throttle lever back, you decrease the gas flow to the engine and control the golf cart’s speed. This governor can be adjusted by adjusting the cable nut which holds the cable to the throttle lever.
How do you remove the speed limiter on a EZ Go golf cart?
General Instructions
- Detach the cable from the carburetor. The cable is about the width of a straw.
- Follow the disconnected cable up to the governor.
- Disconnect the gas pedal cable from the governor and reroute it to the carburetor.
- Using your wrench, remove the bolt on the gas pedal shaft.
Why does my electric golf cart go slow uphill?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart’s slow speed.