One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
How do you remove the speed limiter on a EZ Go golf cart?
General Instructions
- Detach the cable from the carburetor. The cable is about the width of a straw.
- Follow the disconnected cable up to the governor.
- Disconnect the gas pedal cable from the governor and reroute it to the carburetor.
- Using your wrench, remove the bolt on the gas pedal shaft.
Can you make a gas golf cart go faster?
Increase the RPM An increase in the input shaft rpm for all differential ratios will produce a higher speed. For a gas golf cart, other than adjusting the governor, the speed may be enhanced by replacing the engine with a higher rpm output model.
How do you adjust the governor on a EZ Go golf cart?
How to Adjust the Governor on a Gas E-Z-Go Golf Cart
- Locate the governor arm mounted on top of the rear axle case underneath the cart.
- Loosen the adjusting locknut on the end of the governor spring.
- Retighten the adjusting locknut.
Why is my gas golf cart slow?
Low Battery Usually, the most common reason golf carts slow down is when they don’t get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
How can I make my 36v golf cart go faster?
How to Make a 36 Volt Golf Cart Faster
- Remove any unnecessary additions, racks or parts on your golf cart.
- Power-wash your cart.
- Check the shaft under the ignition pedal.
- Put larger tires on the cart.
- Replace any old or worn-out parts that are causing the cart to move slower than it should.
Is 30 mph fast for a golf cart?
What is the Average Golf Cart Speed? The average top speed of a typical golf cart without any upgrades is between 12 and 14 miles per hour. Without any sort of modification or upgrade on a golf cart, the top speed that you will be getting on a golf cart is about 14mph.
How fast does an EZ Go golf cart go?
Electric Motors Looking at the specifications for EZ Go electric golf carts, you notice a cart with a 36-volt motor is capable of 12 to 14 mph top speed. In addition, you notice a cart that’s powered by a 48-volt motor can reach speeds just below 20 mph.
How do you set the speed on a EZ Go golf cart?
Tighten the governor spring located in the engine of most golf carts to adjust your cart’s top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly.
Where is the speed sensor on a ezgo golf cart?
Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.
What does a speed controller do on a golf cart?
The controller meters out current and voltage on your battery based on user input, whether that be a gas pedal, a throttle, or even pedals on a bicycle. With the controller you are able to control your acceleration and deceleration, as well as the speed at which your vehicle moves.
Why does my golf cart slow down going downhill?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart’s slow speed.