- Your Club Car golf cart jerks when taking off, because of a faulty MCOR or low battery charge. Wiper arms that are adjusted incorrectly can also cause a golf cart to jerk. Faulty MCOR.
What causes a electric golf cart to jerk?
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
Why does my golf cart jerk when I take off?
The most common problem here is likely an issue with the batteries. If the battery is low on power or doesn’t distribute power properly, then the cart may jerk as it accelerates.
Why does my golf cart shake when I accelerate?
Answer: The “ shuddering in forward but seems to run fine in reverse” is a very common issue with the 36-volt resistor coil for Club Cars. The reason for this is this system uses all the batteries for forward and only four for reverse.
How do I know if my golf cart shocks are bad?
Golf cart is experiencing excessive nose diving If the golf car feels like the front end is “nose diving”, it is likely that your shocks are bad. The same can be tested for the rear shocks by putting the golf car in reverse and stopping abruptly. Again, if the rear feels like it is going to bottom out.
Should you charge a golf cart after every use?
Still, golf cart batteries should be recharged after four hours of use. Nobody likes to be stranded. It takes several hours to re-charge golf cart batteries that have gone completely dead. To lengthen the lifespan of batteries, make sure they are fully charged before each use.
What makes a golf cart jump?
A gasoline golf cart will just need a temporary burst of electricity that helps the engine run, allowing the alternator to charge up the battery. However, an electric cart needs not only a jump but a consistent flow of electricity to charge the battery properly.
Why does my electric golf cart go slow uphill?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart’s slow speed.
What would make a golf cart smoke?
The pistons on your golf cart help produce power by compressing your fuel and moving when the spark plug ignites the gas. However, these pistons can get broken or worn down and run improperly. When this happens, your cart is likely to produce a lot of excessive smoke whenever it runs.
What is an MCOR on a golf cart?
Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for ‘ Motor Controller Output Regulator ‘.
How do you balance golf cart tires?
Turn it to the rear of the cart to turn your tire slightly inward and turn the rod out to turn the wheel outward for more of a balance.
What PSI should golf cart tires be?
These tires typically use anywhere from 15 to 25 pounds per square inch (PSI), with the average being 20 to 22 PSI. For golf carts driven off-road or on rougher terrain, it’s not uncommon to under-inflate tires to gain additional traction. However, under-inflated tires wear down prematurely.
Why is my golf cart bumpy?
Correct Tire Pressure If you are not continually checking the pressure in the tires on your cart, you can cause a rough ride, and you can also cause unnecessary wear on the tires themselves. People often notice when golf cart tires are low, but when the tires are too full is also a time for concern.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won’t start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
What happens when golf cart solenoid goes bad?
How Often Does A Golf Cart Solenoid Go Bad? Your solenoid is prone to overheating as a result of its regular use. As a result, you may notice irregular operation after a while — it may work one time, but not the next. Loose cables or dusty interiors could cause your cart’s inability to start.