Golf Cart Shakes When Accelerating? (Solution found)

When the 36-volt resistor coil for Club Cars is used in the forward direction, it is quite typical to have “shuddering in forward yet appears to operate well in reverse.” This is due to the fact that this technique uses all of the batteries for forward motion and just four cells for backward motion.

Why Does My Club car golf cart jerk?

One of the most prevalent causes of jerkiness in a golf cart is that the battery terminal connections have become loose and/or have become corrosiond. It is impossible for the right amount of current to pass via the battery bank to the speed controller or resistor coil, and finally to the electric motor, if the connection is inadequate.

Why is my car shuddering when I accelerate?

It is common to detect your automobile shaking when under severe acceleration if the inner CV joint has been damaged or has begun to fail. When the situation worsens, the mild vibrations become intense shaking when the load is applied. CV joints that have been damaged are typically caused by a tear in the joint boot. The CV joint must be totally replaced in order to be repaired.

How do I know if my golf cart controller is bad?

Failure of the controller is shown by the following symptoms:

  1. Top Speeds are not appropriate for your cart’s capabilities. Golf carts are built to attain fairly specified speeds and to avoid going over or below those speeds. Rapid and unexpected slowing
  2. stuttering or shaky driving
  3. stalling out and refusing to start
  4. sudden and unexpected increases in speed when driving
See also:  What Are The Best 6 Volt Golf Cart Batteries? (Perfect answer)

What causes an electric golf cart to hesitate?

The fact that your cart does not start smoothly, hesitates before beginning, or does not gather speed properly are all indications that your accelerator is defective or broken.

Should you charge a golf cart after every use?

In spite of this, golf cart batteries must be recharged after four hours of operation. Nobody enjoys the feeling of being stuck. It might take many hours to fully recharge golf cart batteries that have been entirely depleted of power. Before each usage, make sure that the batteries are well charged in order to maximize their longevity.

What PSI should golf cart tires be?

These tires generally have a pressure range of 15 to 25 pounds per square inch (PSI), with the average being 20 to 22 pounds per square inch (PSI). It is not commonplace for golf carts that are driven off-road or on tougher terrain to have their tires underinflated in order to get greater grip. Under-inflated tires, on the other hand, degrade more quickly.

Why is my car shaking when I press on the gas?

It’s possible that you have a damaged or broken motor mount. Motor mounts are the components that connect the engine to the chassis of your car. The fact that it sounds severe does not make it any less so. Damage to one or more of the motor mounts can cause the engine to tremor and move about when the gas pedal is depressed.

Why is my gas pedal vibration when I accelerate?

An exhaust leak is likely to be the cause of any vibrations you feel coming from the gas pedal. It is possible that the toxic vapors will escape via a small crack or hole, causing the entire car to shake. However, the feeling will be most noticeable on the gas pedal as you speed as the vehicle moves.

See also:  How Can I Make My Golf Cart Go Faster? (Best solution)

How do you troubleshoot a gas golf cart?


  1. Check the gas tank to make sure there is adequate gasoline for the vehicle’s functioning. Remove the oil dipstick and make sure that the oil level is at or slightly above the add or fill maker before replacing it. The battery in the golf cart should be checked. Take a close look at the wiring and switches. The carburetor may be accessed by removing the air filter from the engine.

What happens when golf cart solenoid goes bad?

What is the frequency with which a golf cart solenoid fails? Because of the frequency with which it is used, your solenoid is susceptible to overheating. Consequently, you may observe erratic operation after a while — for example, it may function one time and not work the next. It is possible that your cart’s difficulty to start is caused by loose wires or filthy inside.

How often should you add water to your golf cart batteries?

When you have finished charging your battery, it is time to add water. Adding water after charging helps to prevent acid from pouring out of the container. You’ll want to fill the battery with water up to 1/2 inch below the top of the battery. 2) We recommend that you get servicing performed once or twice a year.

How do I reset my electric golf cart motor?

First and foremost, you’ll need to reset your motor. In the vicinity of the primary battery supply, there should be a little reset button (which is often red in color). Press the reset button, and then replace the cover on the motor to complete the process. In order to proceed, you should charge your cart and then attempt to switch it on again.

See also:  Why Won'T My Gas Golf Cart Move? (Best solution)

How often should you check golf cart batteries?

Checking the water level in your battery cells at least once every two months is recommended to guarantee that your battery does not run the danger of being wrecked as a result of low water levels. The optimum time to replenish the water in your golf cart batteries is immediately following the completion of a full charge of your golf cart batteries.

How do I test my electric golf cart?

Keep an eye out for a small red button that should be located near the main power supply. After pressing the button, reassemble your cart before connecting it to the charging station. In many circumstances, this will be sufficient to resolve the issue. It may be necessary to remove the motor and test it with a separate, fully charged battery if this is not the case.

Leave a Reply

Your email address will not be published.